Success Stories in Kansas - Mr. Philip Voorhees Oil

Eastern Kansas has long been considered an area with low producing rate oil wells and "poor-boy" type operations with no untapped reservoirs remaining to be discovered. Not so, just ask Philip Voorhees, president of Mr. Philip Voorhees Oil Company. In 1990, Mr. Philip Voorhees drilled the discovery well on the Donley lease in the mature Colony-Welda field in Allen County, within an area which has produced since early this century. That discovery well came in flowing - over 100 BOPD. Since then, the company has drilled 29 more producing wells and 19 water injection wells. What has resulted is one of the most attractive and well engineered oil leases in Eastern Kansas.

photo of Donley tanksThe Squirrel sandstone in the Colony area produces a 29EAPI crude from a typical depth of 830'-870'. Excellent reservoir properties have led to a large number of successful waterfloods over the years in this area. In 1993, Mr. Philip Voorhees began injecting water into a limited number of wells on the lease. Response was timely and the balance of the injectors were drilled and completed in recent months. Current producing rates are in the 110-120 BOPD range and two-thirds of the lease has not yet responded to the waterflood. The lease has recovered 200,000 barrels of oil since discovery. Ultimately, 400-500,000 barrels will be recovered.

Despite all the positive parameters, the Donley has not been without its problems. After several wells had been drilled, and most noticeably after water injection began, it became obvious that the lease was producing from a fractured reservoir. In order to alleviate interwell communication and improve the waterflood sweep efficiency, Mr. Philip Voorhees contracted Fred Gee of Eureka, Kansas to inject about 90 barrels of cross-linked polymer into each of ten injection wells about six months after initial injection began. Now, three years later, the injection pressure has increased, an obvious oil bank has formed within the polymer-treated portion of the reservoir and premature interwell communication has been nonexistent. The balance of the injection wells will be given a similar treatment, as necessary.

In order to obtain a sufficient water supply, a Mississippian supply well was drilled. Unfortunately, the Mississippian is slightly sour and it has been necessary to treat the injection water with biocide. Prior to controlling the problem, serious iron sulfide formation was causing frequent well servicing and replacement of equipment. Since a stabilized biocide program has been instituted, servicing of injection wells has not been necessary. The produced water is disposed of in a shallow carbonate formation rather than being recycled.

With the assistance of Lancer Oil Inc. Mr. Philip Voorhees built a state-of-the-art injection plant. The plant features an individual water line to each injection well, a water treatment plant which requires changing the 10-micron filters only once every two months and a closed-injection system eliminating oxygen from the entire system. A security and integrity monitoring system within the plant notifies company personnel by telephone in case of excessive pump pressures, improper tank levels, malfunctioning of the water supply well pump or the 3-phase electrical system, and unauthorized entry. Mr. Philip Voorhees Oil Company has maximized the potential of this waterflood by using a quality drilling and completion program, excellent equipment, attention to reservoir and chemical properties and workable short-term and long- term operating procedures. The result has been not only a very attractive operation, but, an extremely successful economic venture as producing rates are high and operating costs are well below the industry average for comparable waterfloods in Kansas. Granted, the lease is an exceptionally good one for eastern Kansas, however it remains and excellent example of proper oilfield and reservoir management. The increase in revenues. The additional profit realized will payout the incremental expenses many times over. Now that the chemical problems are under control and the remainder of the lease will soon be responding to the expanded lease-wide waterflood it is anticipated that the producing rate will soon reach about 150 BOPD and hover in that range for possibly as long as two years.

In addition to the companies listed above, the operator wishes to acknowledge Charley Hutton and Chuck Hutton for their valuable input in planning the overall project, and Alan Rader for providing the well completion engineering and electronic monitoring design.

BASIC LEASE PARAMETERS
Mr. Philip Voorhees OIL CO. - DONLEY LEASE

Producing Formation Squirrel Sandstone

Typical Depth

830'-870'

Lease Area

160 acres

Productive Area

80 acres

Average Sand thickness

35 feet

Average Porosity

24%

Average Connate Water Satn.

30%

Oil Gravity

29 EAPI

Current Rate

115 BOPD

In upcoming issues of this newsletter, we will be featuring other oil and gas projects in the region. Consideration will be given to those endeavors which show initiative, are unique and apply technology which is normally available to most people. These projects may be in production, exploration, reservoir management, enhanced recovery or a service industry. If the readers are aware of any such project which may be of interest to others in the petroleum industry we would appreciate your recommendations.

Electronic version placed online October 1997
URL=http://www.kgs.ukans.edu/ERC/PTTC/97News/q97-0-6.html
Original print article in pdf format.